The Enid News and Eagle, Enid, OK


June 15, 2013

Proper hay storage is key

ENID, Okla. — Recent rainfall, combined with rising ambient temperatures in the southern Great Plains, should serve as a signal for agricultural producers to monitor their hay.

Although moderate temperature elevation is normal for baled hay put into storage, excess moisture in forage can result in hay heating to levels capable of spontaneous combustion.

“Whether hay actually burns depends primarily on stack size,” said Ray Huhnke, director of Okl-ahoma State University Di-vision of Agricultural Sci-ences and Natural Re-sources’ Biobased Products and Energy Center.

If heat developed in the pile can readily escape, the hay or straw may only mold or turn a tobacco-smell brown. However, if enough hay or straw is situated around the hot spot to prevent the escape of moisture and heat, the hot spot will burn.

Heating of wet hay or straw occurs in three stages: First, carbohydrates combine with oxygen to yield carbon dioxide, water and heat; temperatures may reach 130 degrees. Second, bacteria and fungi produce heat. This can raise temperatures to 170 degrees.

“In the third stage, oxygen combines with highly oxidizable material produced during second-stage heating,” Huhnke said. “This process starts at about 170 degrees.”

At this point, the situation becomes critical. Temperatures will continue to rise to the kindling point if enough oxygen and moisture are present to generate heat faster than it can escape.

“Monitor piles daily because sometimes it can take as much as a week before signs of a heating problem can arise,” Huhnke said. “If the temperature reaches 140 degrees, recheck every few hours. If the temperature reaches 180 degrees, contact your local fire department. Do not move the hay until the fire department is present.”

A steel rod can initially be used to check pile temperatures by driving it into the pile, waiting for 15 to 20 minutes and then pulling it out. If the rod is too hot to hold by hand, the situation is critical.

Huhnke cautions producers to stack hay in a locale where air can circulate around the pile to allow heat and moisture to escape. If possible, store large bales individually until the danger passes, then store in large stacks.

“Weeds can significantly increase the moisture content of otherwise dry material, so plan accordingly,” he said. “As always, take time to monitor suspect piles and contact your local fire department if there is reason for concern.”

Oklahoma is the eighth-largest hay-producing state in the nation, accounting for approximately $129 million in cash receipts annually.

Text Only
  • farm - Rick Nelson web.jpg Wheat tour to provide crop information

    Damage to wheat from the recent freeze will depend on growth stages and temperatures. It will take approximately seven to 10 days following a freeze to determine damage.

    April 19, 2014 1 Photo

  • FFA logo.jpg Drummond students receive honors

    Several members traveled to Alva for the Northwestern Oklahoma State University Interscholastic Contest.

    April 19, 2014 1 Photo

  • farm - garber ffa web.jpg Garber FFA members place in speech contests

    The Ag 1 quiz bowl team placed fourth and qualified for state. On the second day of the event, the animal science quiz bowl team placed second and qualified for state.

    April 19, 2014 1 Photo

  • Danna Zook cutout web.jpg Producers need to consider cow supplements

    Springtime for many Oklahoma producers often means calving time.

    April 12, 2014 1 Photo

  • Master Gardener logocmyk.jpg It’s time to dirty hands

    Bees are venturing out to visit the new flowers. Keep a close watch on your garden. Often, helpful pest-destroying insects are out, getting ready to work for you, also. These, and the bees helpfully pollinating flowers, shouldn’t be discouraged by the undiscriminating spraying of insecticides.

    April 12, 2014 1 Photo

  • farm - 4H web.jpg 4-H’ers meet with state lawmakers

    Sen. Eddie Fields spoke to the group upon their arrival at the Capitol.

    April 12, 2014 1 Photo

  • Canola tour to have stops in area

    The tour will be held at the canola field of Flying G Farms located 91⁄2 miles west of Orienta on U.S. 412 and then north into the field.

    April 12, 2014

  • farm - Rick Nelson web.jpg Money up front can mean bigger returns later

    Implants are a safe, effective technology that typically offer a 10-to-1 return on investment.

    April 5, 2014 1 Photo

  • FFA logo.jpg 9 area students to receive WLC program scholarships

    FFA members will tour our nation’s capital, visit with members of Congress and perform a service learning project within the Washington area, while building friendships with fellow FFA members from across the nation.

    April 5, 2014 1 Photo

  • FFA logo.jpg NW Oklahoma FFA members named proficiency finalists

    Three finalists are selected in each of 49 agricultural proficiency award categories. The state winner in each area will be announced April 30 during the 88th State FFA Convention held at the Cox Convention Center in Oklahoma City.

    April 5, 2014 1 Photo

Featured Ads